2004 Nissan Frontier Recalls

The riskThe shaft may break which could result in loss of steering control during these low speed maneuvers increasing the risk of a crash.

The fix — freeThe steering column shaft and joint will be replaced with a shaft of a different design. This service will be performed free of charge. The recall began on december 13, 2010. Owners may contact nissan at 1-800-647-7261.

What was foundNissan is recalling certain model year 2002-2004 frontier vehicles manufactured from july 9, 2001 through october 20, 2004, and model year 2002-2004, xterra vehicles manufactured from july 9, 2001, through january 6, 2005. Over time corrosion may form in the lower steering column joint and limit movement of the joint. The limited movement of this joint may create excessive load on the lower steering column shaft. If the vehicle continues to be driven in this condition, it may lead to cracking of the shaft during low speed maneuvers that require large steering inputs.

The riskThis harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. This result would be the lack of trailer braking when the towing vehicle brakes were applied. It would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. The failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.

The fix — freeHopkins will notify owners and replace the original harness with a revised harness free of charge. The recall began august 17, 2007. Owners can contact hopkins at 800-835-0129.

What was foundCertain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. The internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. A wire may have been placed in an incorrect position in the electrical connector housing. This results in an incorrect routing of wires between the trailer brake controller and the towing vehicle wiring system.

The riskLack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

The fix — freeTradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during july 2006. Owners may contact tradesonic at 626-934-8884.

What was foundCertain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

The riskWithout the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.

The fix — freeAnzo will notify owners and replace the headlamps free of charge. The recall began may 9, 2006. Owners may contact anzo usa at 909-468-3688.

What was foundCertain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."