2000 Chevrolet Suburban Recalls

The riskThis condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.

The fix — freeHoneywell will notify owners and replace the fuel filters free of charge. The recall began on october 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1).

What was foundCertain replacement fuel filters, fram brand name p/n G3727, with date codes X52911 through X60801 sequentially or X600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). The connector on the fuel filter was not manufactured to honeywell's specification. As a result, the o-ring may not seat correctly on the fuel line.

The riskWithout the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

The fix — freePro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.

What was foundCertain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

The riskThis can cause increased stopping distances during low-speed brake applications, which could result in a crash.

The fix — freeDealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.

What was foundCertain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (abs) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.

The riskIf the ignition circuit wire is exposed, the fuel pump fuse will blow, disabling the fuel pump and causing an engine stall or no-start condition. If sufficient heat is conducted to the pass-through connector, a hole in the connector may result, which may cause a 'service engine soon' light to be illuminated during the emission system diagnostic routine. Fuel vapor and in some cases liquid fuel may leak out of the fuel tank through the hole in the connector body. Fuel leakage, in the presence of an ignition source, could result in a fire. Also if the ignition circuit or ground wire is exposed and shorts to the fuel level sender card wires, inaccurate fuel level readings may result.

The fix — freeDealers will remove the fuel tank, and remove the module reservoir assemblies from the tank, and install a new service kit free of charge. An interim letter to owners was mailed on may 25, 2005. The owners were re-notified on october 19, 2005, since parts are now availabe. Owners may contact chevrolet at 1-800-630-2438 and gmc at 1-866-996-9463.

What was foundCertain trucks and sport utility vehicles were built with fuel module reservoir assemblies that contain fuel pump wires connectors may overheat under certain operating conditions.

The riskAn inoperative pump can cause increased steering effort, and in hydro-boost equipped vehicles also increased braking effort, but does not completely eliminate the ability to steer or slow the vehicle.

The fix — freeDealers will replace the hydraulic pump. The campaign began on february 14, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.

What was foundSome pickup trucks, vans, and sport utility vehicles equipped with a hydraulic pump driveshaft that can fracture, resulting in immediate loss of hydraulic power steering assist. On certain vehicles equipped with hydro-boost power brakes, the same condition can result in loss of power assist for braking after the reserve pressure is depleted.

The riskThis overheating condition can cause the running board to melt or cause a fire.

The fix — freeDealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.

What was foundCertain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.

The riskIn a vehicle crash, front seat occupants may receive more severe injuries.

The fix — freeDealers will recalibrate the sdm on the affected vehicles. Owner notification began august 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.

What was foundOn certain pickup and utility trucks, some of these vehicles have an air bag sensing diagnostic module (sdm) which contains an anomaly that could result in the driver and passenger's air bag failing to deploy during certain frontal crashes.

The riskTread belt separation may be noticed by irregular wear, noise, or vibration. With continued use, it may lead to complete separation of the tread/belt package from the tire carcass, possibly resulting in a vehicle crash, personal injury, or death.

The fix — freeOn january 2, 2001, firestone made a public announcement of the defect and that replacement tires are immediately available at no cost to the customer. Replacement tires are available at either their local gm or chevrolet dealer or by their local authorized participating firestone retailer. Owner notification began january 1, 2001. Owners should contact firestone at 1-800-465-1904.

What was foundTire description: wilderness le tires (both black and raised white letter tires) produced during the week of april 24, 2000 (the seventeenth week of 2000) at the cuernavaca, mexico plant with tire serial numbers V672WL11700 (blackwall) and V672WL21700 (raised white letters). These tires were used as original equipment on model year 2000 yukon xl 1500 series vehicles and were also offered as optional equipment on the 2000 chevrolet suburban 1500 series vehicles. Tread separation can occur due to a lack of adhesion to the first steel belt.

The riskDuring braking, the pedal will be lower than normal and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.

The fix — freeDealers will inspect the front right-hand brake pipe for wear. If there are signs of wear, this section of the brake pipe will be replaced with a new designed brake pipe section. If there are not signs of wear on the brake pipe, the dealer will install a spacer clip to ensure sufficient clearance between the brake pipe and the body cross sill.

What was foundVehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have a clearance condition between the front right-hand brake pipe and the body cross sill that could decrease to the point of allowing contact during the life of the vehicle. If contact occurs and the brake pipe becomes damaged, in half of the brake system there can be a loss of brake fluid and pressure. The brake warning lamp will be activated when the brake fluid level reaches the indicator limit.

The riskThese gases could flow into the passenger compartment if the plug is missing or loose and could cause possible illness, unconsciousness, or death.

The fix — freeDealers will inspect the vehicle for loose or missing wheelhouse plugs and install new plugs if necessary.

What was foundVehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have loose or missing rear wheelhouse plugs. Under certain vehicle operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse.

The riskThese vehicles do not comply with requirements of fmvss no. 105.

The fix — freeDealers will re-route the brake booster vacuum supply hose.

What was foundVehicle description: light duty pickup trucks and sport utility vehicles equipped with vacuum power, 4-WHEEL disc brakes. These vehicles fail to comply with the requirements of fmvss no. 105, "hydraulic brake systems." These vehicles were built with a kinked brake booster vacuum supply hose.