2011 Hyundai Sonata Recalls

The riskA fuel leak in the presence of an ignition source can increase the risk of a fire.

The fix — freeHyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.

What was foundHyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.

The riskIf the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

The fix — freeHyundai will notify owners, and dealers will install an external wire filter kit, free of charge. The recall began October 15, 2018. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 174.

What was foundHyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying.

The riskIf the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.

The fix — freeHyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.

What was foundHyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

The riskIn the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.

The fix — freeHyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.

What was foundHyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

The riskWith a loss of power steering assist, extra steering effort will be required, especially at lower speeds, increasing the risk of a crash.

The fix — freeHyundai will notify owners, and dealers will replace the EPS control unit, free of charge. The recall began May 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9640. Hyundai's number for this recall is 143.

What was foundHyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured December 11, 2009, to October 31, 2010. In the affected vehicles, the Electronic Power Steering (EPS) circuit board may be damaged and result in a loss of power steering assist.

The riskIf the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to rearward following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.

The fix — freeHyundai will notify owners, and dealers will replace the brake pedal stopper pad with an improved part, free of charge. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 136.

What was foundHyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.

The riskIf a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.

The fix — freeHyundai will notify owners, and dealers will replace the front coil springs, free of charge. Interim notifications were mailed on November 17, 2015. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 133. Note: Vehicles that were previously registered in salt belt states but are currently registered elsewhere are eligible to be inspected and repaired.

What was foundHyundai Motor America (Hyundai) is recalling certain model year 2011 Elantra vehicles manufactured November 12, 2010, to March 31, 2011, and Sonata vehicles manufactured December 11, 2009, to February 28, 2010, originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.

The riskEngine failure would result in a vehicle stall, increasing the risk of a crash.

The fix — freeHyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. Interim notifications were mailed to owners starting on October 8, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.

What was foundHyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.

The riskIf the brake lines leak brake sufficient fluid, the brake warning lamp in the instrument cluster will illuminate and longer stopping distance will be required, increasing the risk of a vehicle crash.

The fix — freeHyundai will notify owners, and dealers will replace the brake hoses with a revised service part, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 122.

What was foundHyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured from December 11, 2009, through September 1, 2010. The affected vehicles may experience a brake fluid leak from the two brake lines that connect the brake system's master cylinder to the Hydraulic Electronic Control Unit (HECU) due to insufficient seal between the inner brake hose and metal brake line fitting.

The riskIf the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

The fix — freeHyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The recall began in September 2014. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.

What was foundHyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.

The riskFailure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

The fix — freeHyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.

What was foundHyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.

The riskImproper assembly or insufficient tightening of the connections could result in a complete separation or compromised attachment of the connections, such that the driver could experience a loss of, or reduction in, steering capability increasing the risk of a crash.

The fix — freeDealers will inspect the steering column intermediate shaft universal joint connections for proper assembly and torque. In addition dealers will update the power steering software free of charge. The safety recall began on october 11, 2010. Owners may contact hyundai customer service center at 1-787-999-3333.

What was foundHyundai is recalling certain model year 2011 sonata vehicles manufactured from december 11, 2009, through september 10, 2010. On some of these vehicles the steering column intermediate shaft universal joint connections may have been either improperly assembled or insufficiently tightened.

The riskImproper assembly or insufficient tightening of the connections could result in a complete separation or compromised attachment of the connections, such that the driver could experience a loss of, or reduction in, steering capability increasing the risk of a crash.

The fix — freeDealers will inspect the steering column intermediate shaft universal joint connections for proper assembly and torque. In addition dealers will update the power steering software free of charge. The safety recall is expected to begin during october 2010. Owners may contact hyundai customer assistance center at 1-800-633-5151.

What was foundHyundai is recalling certain model year 2011 sonata vehicles manufactured from december 11, 2009, through september 10, 2010. On some of these vehicles the steering column intermediate shaft universal joint connections may have been either improperly assembled or insufficiently tightened.

The riskThe door may not be in the locked position and may open while the vehicle is in motion, possibly resulting in injury to the driver or passenger.

The fix — freeHyundai-kia will notify owners and dealers will repair the vehicles by replacing latches affected by this recall campaign free of charge. The safety recall began on march 12, 2010. Owners may contact hyundai customer assistance center at 1-800-633-5151.

What was foundHyundai-kia has notified nhtsa about a defect in certain model year 2011 sonata vehicles manufactured from december 11, 2009 through february 15, 2010. The front inside door lock switch can remain in the unlatched position.