2005 Honda Odyssey Recalls

The riskA vehicle that runs out of fuel and stalls has an increased risk of a crash.

The fix — freeDelphi has begun notifying dealers and distributors, and will replace the fuel pump modules, free of charge. Owners may contact Delphi customer service at 1-877-411-8770. Delphi's number for this recall is GL14-004.

What was foundDelphi Automotive Systems, LLC (Delphi) is recalling certain replacement fuel pump modules, part number FG1155-11B1, sold for use in 2005-2010 Honda Odyssey vehicles. The affected fuel pump may send an incorrect fuel reading to the fuel gauge possibly causing the vehicle to run out of fuel. The fuel gauge will always read 3/4 full to full regardless of the actual level.

The riskA fuel leak increases the risk of a fire.

The fix — freeParts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover will get a replacement, original cover. All vehicles, including those receiving the interim repair, will get an improved cover when they are available. Owners may contact Honda at 1-800-999-1009. The recall numbers associated with this campaign are JD9 (inspection and/or preliminary part replacement) and JE0 (final parts replacement).

What was foundAmerican Honda Motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda Odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover may deteriorate allowing fuel to leak out.

The riskA leak of brake fluid could lead to a change in brake pedal feel and overtime a degradation in braking performance increasing the risk of a crash.

The fix — freeDealers will replace the brake master cylinder seal free of charge. The recall is expected to begin during december 2010. Owners may contact honda at 1-800-999-1009.

What was foundHonda is recalling certain model year 2005-2007 odyssey and acura rl vehicles. Brake fluid containing polymers is used that acts as a lubricant for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder may become dry, and the seal may curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak from the seal into the brake booster.

The riskInjury may result from a power liftgate closing unexpectedly when a person is within the closing path of the liftgate.

The fix — freeDealers will inspect the gas liftgate struts and replace if within the recall population. This service will be performed free of charge. The campaign began on march 26, 2010. Owners may contact honda automobile customer service at 1-800-999-1009.

What was foundHonda is recalling certain model year 2005 odyssey touring vehicles equipped with power operated rear liftgate. The power liftgate gas struts may deteriorate unexpectedly early. Struts that have worn out prematurely may fail to hold the power liftgate in the fully open position, causing the power liftgate to close unexpectedly.

The riskIf the fuel pump loses power while driving, the engine could stall without warning, and a crash could occur.

The fix — freeDealers will inspect and replace the fuel pump relay free of charge. The recall began on april 2, 2007. Owners may contact honda at 1-800-999-1009.

What was foundOn certain vehicles, a coil wire inside the fuel pump relay may break, causing the fuel pump to lose power. If the fuel pump becomes inoperative, the engine may not start.

The riskFront impact sensor failure could cause a delay in, or loss of, frontal air bag deployment, which can increase the risk of injury in a frontal crash.

The fix — freeDealers will replace the front impact sensors. The recall began on august 30, 2005. Owners may contact honda at 1-800-999-1009.

What was foundThe frontal air bag system has two external impact sensors. On certain mini vans,some sensors were insufficiently sealed during manufacturing. If water enters a sensor, corrosion can occur. Corroded sensors could short circuit internally. If sensors fail, the srs warning lamp on the instrument panel will turn on and remain illuminated.

The riskIf the fuel pump loses power while driving the engine could stall without warning which could result in a crash.

The fix — freeDealers will replace the entire fuse box free of charge. The recall began on april 13, 2005. Owners may contact honda at 800-999-1009 or acura at 1-800-382-2238.

What was foundOn certain passenger vehicles, a loose terminal in the main fuse box may cause the fuel pump to lose power. If the fuel pump becomes inoperative, the engine may not start.

The riskLoss of steering control can cause a vehicle crash without prior notice.

The fix — freeOwners were notified by telephone on january 25, 2005, and arrangements were made to have their vehicles towed to their dealers and have the repairs performed. The recall began on january 25, 2005.

What was foundOn certain minivans and sport utility vehicles, the steering column may be incorrectly assembled, which could result in a loss of steering control.

The riskThe driver could experience a loss of brake force and a crash could occur.

The fix — freeDealers will inspect the rear wheel speed sensors. If an incorrect gap is detected, the sensor will be removed and the knuckle checked for cross threading damage. If damage is found, the knuckle will be replaced. If no damage is found, the sensor will be reinstalled correctly. The recall began on november 12, 2004. Owners should contact honda at 1-800-999-1009.

What was foundOn certain minivans, the anti-lock brake system (abs) uses a sensor on each wheel to detect wheel speed. Some sensors on the rear wheels were installed incorrectly, which means the sensor may report the wrong wheel speed to the abs control unit.