2004 Volvo XC90 Recalls

The riskAn overheated battery could lead to a fire.

The fix — freeVolvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

What was foundVolvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.

The riskIf the condition occurs vehicle owners may notice fuel smell and/or fuel leak which, in the presence of an ignition source, could result in a fire.

The fix — freeDealers will inspect the fuel pump installed in the vehicle, and if necessary replace the fuel pump with a part of a modified design. This service will be performed free of charge. The safety recall began on january 15, 2010. Owners may contact volvo at 1-800-458-1552.

What was foundVolvo is recalling certain model year 2001-2005 S80, model year 2001-2004 V70, S60, XC70 and model year 2003-2005 XC90 vehicles sold in or registered in the states of alabama, arizona, arkansas, california, florida, georgia, hawaii, kentucky, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, utah, virginia and the u.s. Territories. When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange.

The riskThe driver may notice that the vehicle is difficult to maneuver increasing the risk of a crash.

The fix — freeDealers will replace the outer ball joint tie rods with improved outer ball joint tie rods free of charge. The recall began on june 23, 2006. Owners may contact volvo at 1-800-458-1552.

What was foundOn certain passenger vehicles,the outer tie rod ball joint can deform at high loads causing a loss of the clamping force and the nut may loosen, which may eventually lead to a fatigue fracture of the outer tie rod ball joint.

The riskInoperative wipers under inclement weather conditions could cause a crash due to impaired visibility.

The fix — freeDealers will replace the wiper arms and retaining nuts. The recall began on september 5, 2006. Owners may contact volvo cars at 1-800-458-1552.

What was foundOn certain vehicles, if the wiper arm is activated in extreme winter weather conditions and without lifting the wiper arms and cleaning the windshield prior to moving, the wiper arm might slip on its driveshaft, resulting in an inability to move the wipers from the park position.

The riskThis can adversely affect a number of vehicle functions, including brake, engine, transmission, and torque distribution control which rely on this signal for proper operation.

The fix — freeDealers will replace the front wheel sensors. Owner notification began on december 8, 2003. Owners should contact volvo cars at 1-800-458-1552.

What was foundOn certain sport utility vehicles, the front wheel speed sensors may be defective, causing an erroneous wheel speed signal.

The riskIn the event of a crash, the seat occupant may not be properly restrained, increasing the risk of injury.

The fix — freeDealers will inspect and repair the second and/or third row seat belt attachments. Owner notification began on december 8, 2003. Owners should contact volvo at 1-800-458-1552.

What was foundOn certain sport utility vehicles, the seat belt attachment(s) for the second and third row seat(s) may not have been fitted properly.