2004 Volkswagen Passat Recalls

The riskA failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

The fix — freeGates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

What was foundThe Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

The riskA heat shield that may contact the exhaust system can result in a vehicle fire. In addition, a fuel leak from a fuel line or fuel tank ventilation valve, in the presence of an ignition source, can lead to a vehicle fire.

The fix — freeDealers will install additional underbody heat shields on vehicles with automatic transmissions to cover the possibly damaged areas and flash all 1.8T engines with a precautionary software update. Dealers will also inspect and adjust the fuel line routing on 1.8T vehicles and the fuel tank ventilation valve on 4MOTION/ALL wheel drive vehicles, and replace components if necessary free of charge. The recall began on june 13, 2008. Owners may contact volkswagen at 1-800-822-8987.

What was foundVolkswagen is recalling 412,000 my 1999-2005 passat (5TH generation) vehicles equipped with automatic transmissions and produced after june 14, 1999. These vehicles may have an underbody heat shield that can become damaged. In addition, affected vehicles with automatic or manual transmissions may have a fuel line (1.8T engines only) or fuel tank ventilation valve (4MOTION/ALL wheel drive only) that can leak due to fracture.

The riskThe brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

The fix — freeDealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06V-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the vin number of the vehicle. Owners may contact vw at 1-800-822-8987.

What was foundOn certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

The riskFuel leakage in the presence of an ignition source may lead to a fire.

The fix — freeDealers will replace the diesel pump. The recall began on february 8, 2005. Owners should contact volkswagen at 1-800-822-8987.

What was foundOn certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.